Recently, many regions have issued warnings of heavy pollution weather and initiated corresponding control measures, which restrict the production and transportation of cement and other industrial enterprises to a certain extent. To be specific:
Zhengzhou City: After research, it was decided to issue an orange warning for heavy pollution weather, and the level II response for heavy pollution weather will be launched at 22:00 on October 8, 2024, and the lifting time will be notified separately. In terms of emission reduction of
industrial sources, industrial enterprises should stop production or limit production according to the "one factory, one policy". Strictly supervise relevant enterprises to implement seasonal control production measures, and supervise coal-fired power generation enterprises to increase the proportion of high-quality coal use. Do a good job of enterprise power dispatch. Strengthen the supervision of coal-fired power generation enterprises to ensure that emissions meet the standards; increase the frequency of law enforcement and inspection of key air pollution sources, urge the efficient operation of air pollution prevention and control facilities, and strictly implement emission reduction measures. The pollutant emissions of enterprises exempted and not included in the control shall not increase compared with those before the warning. Industrial enterprises that are in the state of shutdown during the emergency response period shall not start the furnace without approval. In terms of emission reduction of
dust sources, construction sites should stop earthwork operations , outdoor spraying, painting, cutting, welding and other gas-related operations, mines should stop open-air operations, mining, transportation, repair and other production activities that produce dust. Sand and gravel factories, stone factories and slate factories shall stop open-air operations. All bulk materials piled up in the open air at construction sites and industrial enterprises shall be covered, and the frequency of sprinkling shall be increased during the non-freezing period. On the basis of daily road cleaning frequency for main and secondary roads in urban areas, roads in urban-rural fringe areas, important national roads, provincial roads, city roads and county roads, when the air humidity is less than 50% and the temperature is higher than 5 ℃, dust collection, sweeping, sprinkling, spraying and other dust prevention and control operations shall be increased twice; when the air humidity is greater than 50% or the temperature is lower than 5 ℃, sprinkling, spraying and wet sweeping operations shall be stopped. In terms of
mobile source emission reduction, the city stopped construction clearance (construction waste, dregs), cement concrete, asphalt concrete, sand and gravel transportation . Stop the transportation of building materials, decorative building materials and bulk cement within the Fourth Ring Road in the urban area (except for the use of pure electric and hydrogen energy vehicles) . Enterprises in key industries such as electric power, coal, foundry, building materials and non-ferrous metals shall give priority to railway and pipeline transportation, and the rest shall be transported by new energy or vehicles of the sixth national standard; enterprises involved in bulk material transportation shall be encouraged to stagger peak transportation, reserve production materials, and try their best to reduce vehicle transportation during the warning period.
for Industrial Enterprises Industrial enterprises shall strictly comply with the Emergency Measures for Heavily Polluted Weather in Hengshui City The orange warning emission reduction measures in the List of Emission Reduction Measures (September 2024) shall be implemented, and the gas-related enterprises not included in the list shall be implemented in accordance with the measures to stop gas-related processes or production lines.
(2) Mobile source pollution reduction measures
shall prohibit the use of non-road mobile machinery (except emergency maintenance machinery) in construction sites, factories of industrial enterprises and industrial parks with national emission standards of 2 or below. Materials and products in
steel, ready-mixed concrete, ready-mixed mortar, asphalt concrete and other industries are transported by pure electric, fuel cell heavy-duty trucks or heavy-duty trucks (including gas) with the Sixth National Emission Standard (except special vehicles and dangerous chemicals vehicles). Other units involved in the transportation of raw materials and products are prohibited from using heavy cargo vehicles (including gas) with emission standards of the Fourth National Standard and below for transportation (except special vehicles and dangerous chemicals vehicles). Among them, units using more than 10 vehicles per day should be included in the scope of key supervision.
(3) Measures to
reduce pollution from dust sources should be taken to strengthen dust control at construction sites and in traffic. In addition to emergency rescue, in principle, the construction site should prohibit the construction of earthwork, building demolition, spraying and painting, slope protection and other gas-related construction according to law. Transport vehicles such as coal, dregs, sand and gravel, which are easy to scatter without sealing devices, are prohibited from going on the road according to law.
Shijiazhuang: Level II emergency response for heavy pollution weather will be launched at 12:00 on October 3, and the lifting time will be notified separately.
(1)
According to the requirements of Shijiazhuang Heavy Polluted Weather contingency plan and the list of emergency emission reduction of industrial enterprises, industrial enterprises in the whole city strictly implement various emergency emission reduction measures in accordance with the law.
(2)
In addition to urban operation guarantee vehicles and special vehicles performing tasks, heavy and medium-sized diesel and gas trucks, tricycles, low-speed trucks and tractors are prohibited in urban built-up areas and counties (cities and districts). In construction sites, industrial enterprises and industrial parks, the use of non-road mobile machinery (except emergency maintenance machinery) with emission standards below the second national standard shall be stopped. Steel, electricity, Cement (III) Non-point Source Control Measures
In addition to emergency rescue and livelihood security projects, Earthwork, building demolition, spraying and painting, slope protection and other processes will be stopped throughout the day at the construction site, and the frequency of sprinkling and dust suppression will be increased. Vehicles transporting coal, dregs, sand and gravel without airtight devices are prohibited from going on the road. Mines, sand and gravel factories, stone factories and slate factories shall stop open-air operations according to law (enterprises participating in performance rating shall be implemented in accordance with performance rating measures).
Mobile source control measures. In construction sites, industrial enterprises and industrial parks, the use of non-road mobile machinery (except emergency maintenance machinery) with national emission standards of II or below should be stopped. Materials and products in iron and steel, coking, cement clinker, ready-mixed concrete, ready-mixed mortar, asphalt concrete and other industries are transported by pure electric, fuel cell heavy-duty vehicles or heavy-duty vehicles (except special vehicles and dangerous chemicals vehicles) with the Sixth National Emission Standard (including gas). Other units involved in the transportation of raw materials and products shall prohibit the use of heavy cargo vehicles (except special vehicles and dangerous chemicals vehicles) with emission standards of the Fourth National Standard and below (including gas). Among them, the daily entry and exit of more than 10 vehicle units should be included in the scope of key supervision.
Non-point source control measures. Strengthen dust control in mines, construction sites and traffic. Mines, sand and gravel factories, stone factories, slate factories, etc. shall stop open-air operations in accordance with the law (enterprises participating in performance rating shall implement the performance rating measures) ; except for emergency rescue, in principle, earthwork operations, building demolition, spraying and painting, slope protection shotcrete, etc. Are prohibited in accordance with the law at the construction site; Transport vehicles such as coal, dregs, sand and gravel, which are easy to scatter without sealing devices, are prohibited from going on the road according to law.
Cangzhou: An orange alert for heavy pollution weather was issued at 12:00 on October 3, and a level II emergency response was initiated. The lifting time will be notified separately.
1. The control measures
of industrial enterprises shall strictly implement the emission reduction measures in accordance with the requirements of orange early warning control in the emergency emission reduction list of heavy polluted weather in Cangzhou City.
2. Mobile source control measures
Construction sites, industrial enterprises and industrial parks should stop using non-road mobile machinery (except emergency maintenance machinery) with national emission standards of 2 or below. Materials and products in iron and steel, coking, cement clinker, ready-mixed concrete, ready-mixed mortar, asphalt concrete and other industries are transported by pure electric, fuel cell heavy-duty vehicles or heavy-duty vehicles (including gas) with the Sixth National Emission Standard (except special vehicles and dangerous chemicals vehicles) . Other units involved in the transportation of raw materials and products are prohibited from using heavy cargo vehicles (including gas) with emission standards of the Fourth National Standard and below for transportation (except special vehicles and dangerous chemicals vehicles). Among them, the daily entry and exit of more than 20 cargo vehicles, daily transport volume of more than 150 tons or more than 5 heavy cargo vehicles are included in the scope of key supervision.
3. Non-point source control measures
to strengthen construction site and traffic dust control.Sand and gravel factories, stone factories, slate factories, etc. shall stop open-air operations in accordance with the law (enterprises participating in the performance rating shall implement the performance rating measures); except for emergency rescue, in principle, earthwork operations, building demolition, spraying and painting, slope protection and shotcreting operations are prohibited in accordance with the law at the construction site; Vehicles transporting coal, muck, sand and gravel that are not equipped with airtight devices and are prone to scattering are prohibited from going on the road according to law; pavement operation of linear engineering is prohibited.
4. Safeguard measures
should be carefully organized and implemented by counties (cities, districts) and relevant departments, strengthen supervision and inspection, strictly enforce law enforcement and supervision, and ensure that emergency response measures are in place. Municipal and county emergency management departments shall assist key enterprises whose production processes cannot be interrupted in safety production during emergency emission reduction, so as to ensure that no safety accidents occur in industrial enterprises. During the emergency response period, in strict accordance with the emergency emission reduction list, classified measures, hierarchical management and control, performance classification for A-level and leading enterprises, can independently take emergency emission reduction measures ; Enterprises and projects included in the people's livelihood exemption of the Ministry of Ecology and Environment should fully guarantee normal production, ensure the effective operation of pollution prevention and control facilities, strictly implement pollution prevention and control measures, do not limit production, do not stop production, do less inspection, do less disturbance, encourage enterprises to reduce emissions independently, and resolutely prevent "one size fits all".
Xingtai: Level II (orange) emergency response will be activated at 10:00 on October 3, 2024, and the lifting time will be notified separately.
(1) The management and control measures
of industrial enterprises in the whole city shall be strictly implemented in accordance with the requirements of Grade II (orange) emergency response emission reduction measures in the List of Industrial Sources for Emergency Emission Reduction of Heavy Polluted Weather in Xingtai City 2023-2024.
(2) Construction site management and control measures
should be taken to strengthen dust control in mines, construction sites and traffic. Mines, sand and gravel factories, stone factories, slate factories, etc. shall stop open-air operations in accordance with the law (enterprises participating in the performance rating shall be implemented in accordance with the performance rating measures); except for emergency rescue (included in security projects), in principle, earthwork operations, building demolition, spraying and painting, slope protection and shotcrete operations are prohibited in accordance with the law at the construction site; Transport vehicles such as coal, dregs, sand and gravel, which are easy to scatter without sealing devices, are prohibited from going on the road according to law.
(3) Mobile source control measures
shall stop the use of non-road mobile machinery (except emergency maintenance machinery) in construction sites, factories of industrial enterprises and industrial parks with national emission standards of 2 or below. Materials and products in iron and steel, coking, cement clinker, ready-mixed concrete, ready-mixed mortar, asphalt concrete and other industries are transported by pure electric, fuel cell heavy-duty vehicles or heavy-duty vehicles (including gas) with the Sixth National Emission Standard (except special vehicles and dangerous chemicals vehicles) . Other units involved in the transportation of raw materials and products are prohibited from using heavy cargo vehicles (including gas) with emission standards of the Fourth National Standard and below for transportation (except special vehicles and dangerous chemicals vehicles). Among them, the daily entry and exit of more than 10 vehicle units should be included in the scope of key supervision.
Harbin: Harbin Heavy Pollution Weather Emergency Command Office decided to start the three-level (yellow) emergency response measures from 16:00 on the 8th.
It is reported that in the three-level response, the emission reduction ratio of particulate matter, sulfur dioxide, nitrogen oxides and other major pollutants in the whole society should reach more than 10%, and the emission reduction ratio of volatile organic compounds should reach more than 10%. The environmental protection department of Harbin carried out environmental law enforcement inspection overnight to check the operation of air pollution prevention and control facilities and on-line monitoring facilities of enterprises, as well as the discharge of pollutants; to check the coverage of coal, slag, coke, sand and other materials in industrial enterprises. Other departments such as the Harbin Industry and Information Technology Commission and the Construction Commission have also launched corresponding emergency sub-plans to strictly control the industries under their jurisdiction.
